Webastoto Air Top 3500 Bedienungsanleitung PDF herunterladen

Ident-Nr. 9011433A 05/0406

Operating and servicing

instructions

Air Top 3500

Air Top 5000

be operated using the diesel fuel prescribed by the

vehicle manufacturer. Class EL heating oil (not L heating

oil) may also be used as long as it complies with the

normal quality available on the German market pursuant

to DIN 51603.

We know of no negative influences due to additives.

If fuel is extracted from the vehicle's tank, follow the

additive instructions issued by the vehicle manufacturer.

If you change to low-temperature fuel, the heater must be

operated for approx. 15 minutes so that the fuel system is

filled with the new fuel.

be shut down by removing the fuse if lots of smoke,

unusual combustion noise or a smell of fuel develops.

Do not restart it until the heater has been tested by

Webasto-trained personnel.

be started at least one per months with a cold engine and

at the lowest blower setting for 10 minutes. The heater

must be checked by an expert at the latest at the start of

the cold weather.

The heater :must

General information

Maintenance and safety instructions

Dear Webasto user

We presume that the principle and mode of operation of your new heater has been

explained to your complete satisfaction by the workshop / service centre which

installed the heater. This manual summarizes the main points of importance for using

the heaters Air Top 3500 and Air Top 5000.

The heater has been type-tested and approved in

accordance with EC Directives 72/245/EEC (EMC) and 2001/56/EC (heater) with the

following EC permit numbers: e1*72/255*95/54*1221*--

e1*2001/56*0015*--

e1*2001/56*0016*--

The year in which the heater was used for the first time must be permanently displayed

on the factory plate be deleting the inapplicable years from the plate.

To install the Air Top 3500 and Air Top 5000 heater in hazchem vehicles,

the requirements of ADR/RID part 9 para. 9.2.4.7 Combustion heating systems, must

also be satisfied.

Keep the hot air inlet and hot air outlet free of dirt and foreign bodies.

Contaminated or blocked hot air lines may cause overheating and thus result in the

overheating cut-out tripping.

Do not stand on the heater and do not place any heavy items on the heater or throw

items at the heater.

Do not place any items of clothing, textiles or similar materials over the heater or in front

of the hot air inlet and the hot air outlet.

The current of hot air in the heater must not be restricted or blocked by highly

inflammable substances or materials such as rags, cleaning wool, etc.

Air Top 3500 / Air Top 5000

NOTE:

The provisions of these Directives are binding within the territory governed by

EU Directive 70/156/EEC and should similarly be observed in countries without

specific regulations!

The heaters are not designed for heating hazardous substance transport

compartments.

The heaters must be installed as described in the installation instructions. The

installation must be tested in compliance with the statutory regulations for the installation.

For further details refer to the installation instructions.

be exposed to temperatures over +85°C. If it is exposed

to temperatures above this level the electronics may

suffer permanent damage.

be cleaned using a high pressure cleaner.

The heater :must not

at filling stations or tank farms.

in places where inflammable vapours or dust may form

(for example near fuel, coal, wood dust or cereal stores).

in enclosed areas (for example garages), not even if you

use the timer or Telestart.

The heater must not be operated:

Risk of explosion

and asphyxiation

Webasto AG

Kraillinger Strasse 5

- 82131 Stockdorf

http://www.webasto.de

1 2 3 4

Inhaltsverzeichnis

Seite 1 - General information

Ident-Nr. 9011433A 05/0406Operating and servicinginstructionsAir Top 3500Air Top 5000nnnbe operated using the diesel fuel prescribed by thevehicle man

Seite 2 - Ventilation option

NOTE:!Set the rotary knob on the control element to the required temperature.To prevent the hot and combustion air fan from blocking or scraping, ensu

Seite 3 - Combination timer

Switch onGeneralSwitch offOperationError codeSet time/dateView timeProgramStart timeView/DeleteselectedtimesProgramoperatingtimeSet remainingtimeRemot

Seite 4 - NOTE for ADR mode only:

Heater cuts out automaticallyBlack smoke is emitted from the heaterCauseCauseRemedyRemedyTroubleshooting Error code output on combination timer or con